论文编号:CKZS016 论文字数:40018,页数:110 附CAD，外文翻译
摘 要
本设计的井田面积为3.9平方千米，年产量45万吨。井田内煤层赋存比较稳定，煤层倾角28，平均煤厚3.2m，整体地质条件比较简单，在井田范围东部和中央均有断层发育。沼气和二氧化碳含量相对不高，涌水量也不大。根据实际的地质资料情况进行井田开拓和准备方式的初步设计，该矿井决定采用立井家暗斜井二水平开采，设计采用爆破采煤一次采全高回采工艺，走向长壁采煤法，用全部跨落法处理采空区。并对矿井运输、矿井提升、矿井排水和矿井通风等各个生产系统的设备选型计算，以及对矿井安全技术措施和环境保护提出要求，完成整个矿井的初步设计。矿井全部实现机械化，采用先进技术和借鉴已实现高产高效现代化矿井的经验，实现一矿一面高产高效矿井从而达到良好的经济效益和社会效益。
关键词：立井、倾斜长壁、一次采全高、爆破采煤、高产高效
Abstract
This design well field area is 3.9 square kilometers, the annualoutput 450,000 tons. In the well field the coal bed tax saves quitestably, the coal bed inclination angle 28, average coal thick 3.2m,the overall geological condition quite is simple, and central has thefault growth east the well field scope. The methane and the dioxide carbon content relative are not high,wells up the water volume not to be big. Carries on the well fielddevelopment and the standby mode preliminary design according to theactual geological data situation, this mine pit decided uses verticalshaft inside slope two levels mining, the design uses the demolitionto mine coal time picks entire Gao Huicai the craft, moves towards thelong wall mining coal method, with all cross falls law processing topick the depletion region. And to the mine pit transportation, the mine hoist, the mine pitdrains water and ventilates and so on each production system theequipment shaping computation, as well as sets the request to the minepit security technology measure and the environmental protection,completes the entire mine pit the preliminary design. The mine pitcompletely realizes the mechanization, uses the advanced technologyand the model has realized the high production highly effectivemodernization mine pit experience, realizes an ore high productionhighly effective mine pit thus to achieve the good economic efficiencyand the social efficiency at the same time.
Key word: vertical shaft, incline long wall, full-seam mining,demolition mining coal, high yield highly active
目 录
前 言1
1 矿区概况及井田地质特征2
1.1矿区概况2
1.2井田地质特征5
1.3煤层及煤质7
1.4水文地质特征8
1.5煤炭产品的供求现状11
2 矿井储量、年产量及服务年限13
2.1井田境界13
2.2井田储量13
2.3矿井年储量及服务年限18
3 井田开拓19
3.1概述19
3.2井田开拓19
3.3井筒特征25
3.4井底车场28
3.5开采顺序及采区回采工作面的配置40
3.6井巷工程量和建井周期42
4 采煤方法45
4.1采煤方法的选择45
4.2采区巷道布置及生产系统45
4.3回采工艺设计52
5 矿井运输、提升及排水56
5.1矿井运输56
5.2矿井提升63
5.3矿井排水73
6 矿井通风与安全技术措施84
6.1矿井通风系统的选择84
6.2风量机算及风量分配86
6.3全矿通风阻力计算91
6.4扇风机选型95
6.5矿井安全技术措施98
7 矿山环保101
7.1矿山污染源概述101
7.2矿山污染源的防治102
7.3地表塌陷及生态保护措施104
结 论105
致 谢106
参考文献107
黄石工矿集团胡家湾矿井初步设计......